How do you troubleshoot a Club Car golf cart?

There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.

Test the wall socket where you charge your cart.
Expose your golf cart batteries.
Test the batteries for voltage.
Replace dead batteries.
Expose the motor for inspection.
Reset the motor.
Test the cart.

Where is the motor reset button on a club car?

It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.

Why did my golf cart stop working?

Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.

Is there a reset button on an electric golf cart?

Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn’t repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.

What do you do if your golf cart won’t start?

First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don’t hear clicking, it’s time to take a look at your cart’s batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.

How do I reset my electric club car?

Easily Reset the Club Car Golf Cart OBC

Key switch to off.
Set forward/reverse to neutral.
Put tow/run switch to tow.
Disconnect the negative battery terminal from the battery pack.
Put the tow/run switch to run.
Put forward/reverse switch to reverse.
Put key switch to on.

How do you know if your golf cart motor is bad?

You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won’t start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.

Why did my golf cart just stop working?

What are some common problems with club cars?

Common Club Car problems include failure to charge and issues with solenoids failing to click. This results in Club Cars not starting. One problem common with Club Carts is failure to charge, notes Golf Link.

How to troubleshoot a Club Car CART unlimited?

Club Car Troubleshooting. CHECKING CONTROLLER INPUT and OUTPUT. Connect (-) probe to B- terminal. Connect (+) probe to B+ terminal. The reading should indicate approx. 0 volts with the resistor REMOVED and the pedal not pressed in the last 15-30 minutes. Slowly depress accelerator pedal until the solenoid engages.

How does a club car controller degrade over time?

As a controller in the Club Car or golf cart is made up of electrical and electronics components, it degrades gradually over time with the frequency of usage. But usage is not the only factor, controllers and the Club Car parts may also degrade in case of non-usage.

What to do if your club car battery is bad?

Make sure that the batteries are allowed to charge sufficiently before use. If problems with the battery persist, check the connections around them, using thick gloves and taking precautions against battery acid. Batteries can be found under the Club Car seat. However, the Club Car is generally reliable and durable.